The unit confirms to the standards laid down under Environment (Protection) Act, 1986 as far as all emission from the unit as well as ambient air quality and noise is concerned.
The unit provides adequate method of disposal of solid waste to avoid environmental pollution.
The unit discharges domestic effluent to soak pit as per BIS specification.
The unit treats the effluent generated from the Par-boiling section, washing etc. in an effluent Treatment Plant to meet the prescribed standard of the Board for discharge to inland surface water – PH-5.5 – 8.5, SS – 100 mg/l, BOD – 30 mg/l and oil & grease -10 mg/l.
The unit conducts ETP based on biological treatment with Oil Separator, Collection cum Settling tank, filtration unit consisting of gravel, sand & charcoal, aerated lagoon, secondary settling tank and final polishing pond.
The unit provides for a holding pool of 15 days retention period inside the premises to store the treated effluent which remains unutilized for irrigation, particularly during monsoon.
The unit provides dust collector/cyclone to control particulate matter emission in the flue gases emitted through the stack attached to the boiler in order to meet the prescribed standard.
The unit provides portholes and suitable platform in the stack of facilitating stack gas analysis.
The unit provides for keeping the husk ash generated from the boiler in the low-lying area inside the factory premises to be covered with earth.
The unit will conform to the National Ambient Air Quality Standard for residential, the rural and other areas (SPM = 200 mg/m³ - 24/8 hr).
The unit will provide a green belt along the boundary wall of mill and vacant spaces within the mill premises.
The unit shall abide by the provision of Environment Protection Act,1986.
The stack height of chimney attached to boiler shall not less than 30 meters.
The unit will resort to the practice of Rain Water harvesting.
The unit will utilize the treated effluent for irrigation purposes.
